Tag Archives: corona virus

Citroen Berlingo with ABS Wiring Fault.

A 2014 Citroen Berlingo came in to us with an ABS fault to be looked at.

First thing to do was carry out a diagnostic code read to see why the ABS light was on, the particular code for this Citroen Berlingo van related to an open circuit on the rear left wheel speed sensor.

We checked the actual wheel speed sensor for a fault but it checked out ok, next job was to check the wiring from the sensor back to the ABS pump.

Most of the wiring for the rear ABS sensors is hard to access as it runs inside the van. once we had determined that there was in fact a break in the wiring from the left rear sensor and the ABS pump (by checking continuity of the wires) it was time to start stripping the interior and physically check the wiring for a break.

After removing the passenger seats and lifting the carpets to access the wiring we noticed part of the raised carpet flooring had been trapping the ABS wiring loom between a raiser and the body and over time had rubbed through the wiring and caused it to short out against the body.

We repaired the wiring and and rechecked for continuity through the loom which we now had. Time to clear the stored fault codes and check for a wheel speed signal using the live data on our diagnostic scanner, perfect, the signal was good and the same as the rear right wheel, time to rebuild and road test.

Aarons Autos car service garage.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.

Vauxhall Corsa D 1.2 (A12XER) Timing Chain Rattle.

We had this little Vauxhall Corsa 1.2 booked in with us for a ‘really bad engine noise’.

Once the car was in the workshop it became apparent very quickly what the noise was, the Timing Chain was rattling so bad we were surprised it hadn’t jumped a tooth and caused engine damage!

When we were stripping the engine down to put the Timing Tools in place we could see just how badly stretched the chain had become, the crank locking pin went straight in but both cam shafts were out by quite a lot.

There are several variants of the Vauxhall timing chain engines most of which requiring different timing tools which we have, 1.0 – A10XEP, 1.0 – A10XER, 1.2 – A12XER, 1.2 – A12XEL, 1.4 – A14XEL, 1.4 – A14XER, 1.4 – A14NET to name just a few.

Timing Tool A is for the Camshaft Position Rings, Tool F is for the Camshafts.

After removing the timing chain cover we could start to see what had caused the problem, the oil was very black and there was a lot of burnt carbon oil inside all the covers.

All engines require regular servicing to keep them in tip top condition but especially modern engines that run a timing chains rather than a timing belt, we are seeing more and more engines requiring timing chain kits prematurely due to a lack of servicing, poor quality oil or the wrong spec oil.

Once we had replaced the timing chain kit and re-aligned all timing marks it was time to clean all off the engine casings and refit, replace the oil and filter and refill the coolant.

When we removed the oil filter this gave us another indication of what had caused the problem, the middle of the oil filter had been sucked in, caused by the paper element of the filter being completely full of oil carbon and struggling to allow fresh oil through it, which in turn starves crucial parts of the engine of oil (timing chain) allowing them to wear, over heat and stretch.

On this particular car we advised the customer that over the next 20,000 miles they should have several oil and filter changes to help remove carbon deposits that we couldn’t see or get to whilst doing the job and this will help increase the life of their engine.

Aarons Autos car service garage.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.

Humbled by our customers response.

This was our first week back to work after having to close the business and furlough all the staff on the 31st March due to the Corona Virus and what a crazy week it has been.

In the middle of May I made the decision to re-open the garage on the 1st June and put this information on our website and social media platforms.

My initial plan was to only bring out a couple of members of the team from furlough until we had enough work to get everyone back at full pace.

The general response from our customers was amazing, we managed to fully book the first week of June within a couple of days by just using social media and e-mail, at this point I decided we would need the whole team back at work to cope with this work load so we started back on the 1st at 100%.

This was slightly worrying as in the back of my mind I thought we may just be busy for one week and then it would go quiet again and I would have to start furloughing staff again which I really didn’t want to do, how wrong was I.

Monday 1st June was our first day back and by the end of the day we had almost fully booked the following week! Once our customers had realised we were back they were booking in thick and fast, a few customers had been to other garages whilst we had been closed due to necessary repairs or break downs but then rebooked with us and wanted the work checking as they trusted our opinion implicitly.

I hope all businesses manage to return in the same way we have and start to get back to some kind of normality and hopefully get the economy rolling so we can start enjoying life again once this is all over

I would like to say a massive thank you to all of our customers new and old for sticking with us through these very hard and testing times, without whom this Covid19 pandemic may of finished Aarons Autos.

Aarons Autos car service garage.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.

Re-opening on 1st June 2020 to the General Public.

We hope everyone is taking care and doing their best in this strange and worrying time. Trying to fight this Corona Virus is a bigger job than most of us initially thought but we do seem to be getting there and some of those business’s that were affected by Covid19 are starting to re-open.

Aarons Autos will be re-opening its doors as of the 1st June 2020 and once again be offering its excellent ‘Services’ to the general public and local business’s.

We are putting several measures in place to keep our customers and staff safe from the Corona Virus;

We are fitting a Perspex screen across the whole office counter which will have a small cut out for customers to pass keys through and for them to make payments (card payments are preferred but we will accept cash)
We will be enforcing a one customer in reception at a time rule and customers will not be able to wait in the reception area whilst large repairs are being carried out.
All customers vehicles will be wiped down with anti bacterial wipes pre and post work being carried out, technicians will wear gloves whenever possible.
We will be supplying small hand sanitiser bottles for customers and technicians to use after any transactions.
We ask that customers will leave out their ‘Locking Wheel Nut Keys‘ and ‘Service Books‘ where required so we do not have to search around the car trying to find them (reducing contact inside the car).

If you have any other worries or queries please don’t hesitate to contact us.

MOT’s have been extended, but we are urging customers to have their MOT’s carried out as soon as they possibly can (or feel safe enough to do so).

There are several reasons we are suggesting getting your MOT done sooner rather than later;

18 months is a long time for your car to go un-checked, if you had not had your car Serviced just before the ‘Lock Down’ and your MOT was due how do you know if your tyres, brakes or suspension are safe!
Garages are going to be inundated with MOT’s that are actually due on the date you want yours doing (12 month MOT’s) so imagine the difficulty for the garage to deal with double the amount of MOT’s, this is why we suggest contacting us early so we can spread out the work load.
Think of your local Garage. If NO MOT’s are carried out in April or May what will happen next year? Garages will have less work in those months and possibly struggle.

If you would like to book in for the first week of June please contact us by email info@aaronsautos.co.uk or our Facebook page ‘Aarons Autos Derby Ltd‘ if you would like to contact us after the 1st June just call us as normal between 8.30 – 5.00 and we will be happy to help.

Finally, stay safe and take care.

Emergency Work For ‘Key Workers’ Only.

Unfortunately as of the 1st April 2020 we will be closing our doors to the general public due to the Corona Virus (Covid-19) outbreak but will still be offering emergency work for all ‘Key Workers’ so if you are a ‘Key Worker’ and have an issue with your car which is affecting you working or getting to work please contact me directly by email at aaron@aaronsautos.co.uk or through our Facebook page messaging service and I will endeavour to do my best to help.

As for the governments six month extension on MOTs please keep in mind that in six months time when you need an MOT garage’s will already be dealing with MOTs that are due at that point so we are advising customers not to wait the full six months but to plan on getting their’s done as soon as we are out of this lock down, giving garages time to deal with the back log.

18 months from your last MOT is a long time, consider the condition of your car, is it road worthy? Is it safe? When was it last Serviced? The police are checking cars regularly and if your car is found to have any serious defects they are seizing your car!

As a Garage we are allowed to work through the lock down but are choosing to close due to the lack of work at this strange and worrying time, but if you wish to email or Facebook message me through Aaron’s Autos with your details I can get in touch with you the week before we come out of lock down to book in your MOT or any other work required so as to limit any disruption to YOU getting back to work.

Please remember to stay safe and do as much as you can to limit the spread of this Corona Virus (Covid-19). We will get through this.

Keeping Your Car Healthy During Covid-19.

During the strange and worrying time of the Corona Virus it is not only ourselves and our loved ones that we need to consider but also our cars and vans.

Leaving vehicles standing for long periods of time is not good for them, doing just a couple of simple things once or twice a week will help keep your car or van fit and healthy so that when you do need to use it it will be ready and not let you down.

Firstly, start the car or van and allow the engine to run until it starts blowing warm air from the heaters inside the car (make sure to turn the temp to hot so you know when this happens) this will allow the alternator to put charge into the battery and help keep it healthy. This will take around five to ten minutes.

Secondly, when your car or van has warmed up sufficiently, release the hand brake and roll the vehicle backwards and forwards gently applying the brakes to slow you in each direction. This will stop your brakes from seizing on and also move the weight around the wheels reducing the chance of deforming the tyre carcass whilst it is being left standing.

Also it would be beneficial to visually check the tyre pressures by making sure they all look similar, if one looks flatter at the bottom than the others you may need to physically check the pressures with a gauge.

If you are feeling really brave you could check your under bonnet levels such as Oil, Coolant and Screen Wash, but only do this if you feel confident.

For any more information or if you find a problem feel free to contact us on 01332 205070 or by email on info@aaronsautos.co.uk or through our Facebook page.

Aarons Autos car service garage.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.