Tag Archives: aaronsautos

2018 Ford Transit Wet Belt Failure

This Ford Transit was recovered into us after breaking down on the M5, the customer said he suddenly lost all power and pulled into a laybuy.

After a quick investigation it was very apparent that the van had no compression and we suspected the wet belt had failed causing the crank shaft to keep turning without the cam shafts which has caused internal damage.

We removed the front end of the van including head lamps, radiator and bumper to allow easy access to the wet belt cover.

Once we removed the cover we could see that the wet belt had indeed failed, several teeth were missing from the belt which had allowed the crank and cam shafts to turn separately and caused piston and valve contact.

Check your timing belt history! We recommend 80,000 miles or 8 years.

Teeth missing from wet belt

With a quick inspection of the damaged parts we decided it would be cheaper for the customer to fit a reconditioned engine than for us to repair his damaged engine.

Ford are aware of the premature failure of their Wet Belts which on this model were due at 150,000 miles or 10 years but as far as we are aware they are offering no help if the vehicle is out of warranty.

When the new engine arrived we started swapping all auxiliary parts from the old engine to the new engine carefully inspecting for damage or wear in the process, all gaskets and seals were replaced at the same time.

Reconditioned engine from Ford

With the engine and gearbox built up it was time to refit them into the van and get to a stage where we can run the engine and test for any leaks or blows before refitting the front end.

Starting an engine after such a big job is always an intense feeling no matter how confident you are, but after checking and double checking we were happy with our work and we turned the key…….. and voila, life.

We left the engine running for some time to allow the oil and coolant to get up to temperature and so we could check for any problems.

All good so time to refit the front end and road test, after the road test we recheck all levels and hand back to the customer.

Aarons Autos car service garage.

Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.

Volkswagen Scirocco with a leaky Inter-cooler.

This VW Scirocco came into us with an intermittent running fault, it would randomly put the engine management light on and go into limp mode.

Firstly we carried out a diagnostic code read to see if there were any stored codes and what they related to?

Several codes were stored relating to faults in different systems! Oxygen sensor, Boost pressure and EGR system.

We decided to carry out a smoke test on the intake system as all of these faults can be affected by an air or boost leak.

(A Smoke Tester fills a system with lightly pressurized smoke allowing the user to see any small leaks that may not be obvious to the naked eye.)

We found a leak from around the inter-cooler area but the car needed stripping further to be able to access this area, once the bumper had been removed we could see clearly that there was a split in the inter-cooler housing which was small enough to allow the car to still run reasonably well but bad enough to throw out several sensor readings.

Big Strip Down To Remove The Inter Cooler.
Split Inter Cooler.

After we replaced the inter-cooler and cleared all related fault codes we carried out a road test and checked live data, all sensors were reading as they should and the car drove perfectly without putting the engine management light on and no more limp mode.



Your friendly car garage in Derby

Give us a call at Aarons Autos for more info.